Tuesday, September 4, 2018

Roscosmos Boss: Soyuz Pressure Leak Caused by ‘Technological Error’ – Pledges to Find Who Is Responsible

Cosmonaut Sergei Krikalev, left, and Roscosmos Director General Dmitry Rogozin, center, discuss the Aug. 30 leak at the Russian mission control center in Korolev, Russia. Photo Credit: Roscosmos

Last week’s depressurization event at the International Space Station may have been caused by human error, not a micrometeoroid impact, Roscosmos boss Dmitry Rogozin told Russian media. The handling of the problem suggests a lack of proper oversight by the Russian space agency.

At about 7 p.m. EDT (23:00 GMT) Aug. 29, 2018, ground controllers in Houston and Moscow noticed the pressure aboard the ISS dropping. While cause for concern, the NASA-described “minute pressure leak” was slow enough that the six-person Expedition 56 crew was allowed to continue sleeping. At its maximum rate, the station had “weeks” of air left. Once awake on Aug. 30, the crew began troubleshooting the problem.

The source of the pressure drop was isolated to a two-millimeter “microcrack” in the orbital module—the upper section—of the three-part Soyuz MS-09 spacecraft near the vehicle’s toilet and covered by fabric. NASA and Russian officials stressed the crew was in no danger.

The hole was covered first by a temporary application of Kapton tape, which slowed the leak, and more permanently via an epoxy-based sealant.

While the incident on the ISS was apparently solved, a commission on the ground was formed to investigate the cause of the pressure leak. Many speculated that it could have been a micrometeoroid strike. However, Rogozin, the director general of the Roscosmos state-run space corporation told reporters otherwise.

“We are considering all the theories,” Rogozin said. “The one about a meteorite impact has been rejected because the spaceship’s hull was evidently impacted from inside. However it is too early to say definitely what happened.”

Rogozin said the microcrack seemed to have been caused by a “faltering hand,” and was a “technological error” by a specialist.

“It was done by a human hand—there are traces of a drill sliding along the surface,” Rogozin said. “We don’t reject any theories.”

According a Sept. 3 RIA Novosti report, an industry source said the hole was likely formed when an employee of the spacecraft’s manufacturer, RSC Energia, made an “error,” drilling a hole in the internal hull of the module before sealing the crack with a “special glue.” As such, the leak was not detected during pressurization tests before integrating the spacecraft with the launch vehicle.

Soyuz MS-09 was ultimately given a clean bill of health and launched June 6, 2018, with Russian cosmonaut Sergey Prokopyev, European Space Agency astronaut Alexander Gerst and NASA astronaut Serena Aunon-Chancellor.

“However, [once in orbit], the glue dried and was squeezed out, opening the hole,” a second source told RIA Novosti.

Rogozin told reporters the investigation commission is looking into whether the hole formed because of negligence or was deliberate, according to RIA Novosti.

Soyuz MS-09 is currently docked to the Rassvet module and is expected to remain attached to the ISS until mid-December (essentially making it a temporary component of the ISS). Prokopyev, Gerst and Aunon-Chancellor are expected to return to Earth using that spacecraft. The hole, should its repair hold, is not expected to impact landing procedures as it is in a part of the craft that does not return to Earth.

During the Aug. 30 repair process, Expedition 56 commander and NASA astronaut Drew Feustel was uncomfortable with the plan and requested more time, 24 hours, to allow teams on the ground to test the procedure.

Feustel is the commander of the space station itself. However, the incident was on the Soyuz MS-09 spacecraft, of which Russian cosmonaut Sergey Prokopyev was the commander.

“I would really like to see a test of that, somehow, on the ground before we do a test up here and see if it’s going to work,” Feustel said. “We sort of feel like we’ve got one shot at it and if we screw it up, then the implications are one of these vehicles is going home, or that vehicle is going home, sooner than later.”

While Moscow and the two cosmonauts waited an hour or so, the decision was made to go ahead with the epoxy solution. Once applied at around 12:30 p.m. EDT (16:30 GMT) Aug. 30, a small bubble appeared over the hole, but the pressure leak appeared to have stopped. The crew was instructed to let it set overnight. According to Tass, a second layer of the sealant was added on Aug. 31, and the pressure continued to hold stable.

Rogozin said it is a matter of honor for RSC Energia to “find the one responsible” and to find out whether it was an accident or deliberate and where it was done, be it on the ground or by one of the crew members in orbit.

“It is essential to see the reason, to learn the name of the one responsible for that,” Rogozin said. “And we will find out, without fail.”

Written by: Derek Richardson
Original source: spaceflightinsider.com


  1. This great article can be found as the most important in the area of life of people, so prospect hall casino is one of the most interesting places here.

  2. I am happy with your article, Fajartoto think your website is pretty good. Many articles are very useful for everyone. I am sure your website will grow in the future. Fajartoto will always support your website, hopefully more advanced. keep the spirit... thanks

    agen togel terpercaya
    togel online
    bandar togel terpercaya
    bandar togel terbaik
    situs togel online
    situs togel terbesar
    judi roulette online
    prediksi togel jitu
    syair togel hk